Filter
Top Products
10 John Deere Hand Carry Gasoline Air Compressor Manual
DANGER
RISK OF EXPLOSION OR FIRE
CAUSING SERIOUS INJURY
OR DEATH!
Do not smoke while
fueling!
Do not fill fuel tank while air
compressor is running or
hot. Allow air compressor
and engine to cool down
for two minutes before
refueling. Do not fill fuel tank
to point of overflowing. Allow
approximately 1/4" of tank
space for fuel expansion.
WARNING
RISK OF EXPLOSION OR FIRE
CAUSING SERIOUS INJURY
OR DEATH!
Do not place unit
in an area where flammable gas
vapors may be present. A spark
could cause an explosion or
fire.
Always store fuel away from
the air compressor while it is
running or hot.
WARNING
RISK OF ASPHYXIATION!
Do not operate in an enclosed
area. Use this product only
in well ventilated areas! The
exhaust from the engine
contains carbon monoxide,
a poisonous, odorless and
invisible gas. Breathing the
gas can cause serious injury,
illness and possible death.
INITIAL SET-UP:
1. Read safety warnings before setting-up air compressor.
2. This unit is shipped without oil in the engine and compressor crankcases.
Compressor Pump: Remove oil dipstick and fill with approximately 4
ounces of SAE 30W non-detergent oil. The oil level should not exceed
the top raised line on the dipstick.
Engine: Remove oil cap (follow engine manufacturer's specifications
in engine manual) and fill the crankcase to the proper level. Always use
quality 4-stroke automotive detergent oil.
LOCATION:
1. In order to avoid damaging the air compressor, do not operate the air
compressor when it is inclined in any direction more than 10°.
2. Place air compressor at least 12 inches away from obstacles that may
prevent proper ventilation. Do not place air compressor in an area:
-where there is evidence of oil or gas leaks.
-where flammable gas vapors or materials may be present.
-where extremely dirty air or water could be drawn into the air
compressor.
GASOLINE ENGINE:
1. Review "Risk of Fire or Explosion" pg. 4 before fueling.
2. Read the engine manual accompanying this air compressor for correct
engine start-up maintenance procedures.
3. Read and understand the safety labels located on the air
compressor.
4. A minimum of 85 octane fuel is recommended for use with this air
compressor. Do not mix oil with gasoline.
5. Use of clean, fresh, lead free gasoline is recommended. Leaded
gasoline may be used if lead free is not available. Do not use gasoline
containing methanol or alcohol.
6. Fill the fuel tank according to the engine manual instruction.
7. Refer to the engine manual for all necessary maintenance and
adjustments.
PRE-START CHECKLIST:
1. Check oil levels. Add oil if necessary.
2. Remove any moisture in the air compressor air tank. NEVER attempt
to open the Air Tank Drain Valve when more than 10 PSI of air pressure
is in the air tank! Remove excessive pressure with an air tool,
then open the Air Tank Drain Valve in the bottom of the air tank.
Close tightly when drained.
3. Make sure the Engine Switch is in the "OFF" position.
4. Make sure the Pressure Relief Valve is working correctly.
PREPARATION
WARNING
RISK OF BODILY INJURY!
Never attempt to open the Air
Tank Drain Valve when more than
10 PSI of air pressure is in the air
tank!
WARNING
RISK OF EXPLOSION OR FIRE
CAUSING SERIOUS INJURY OR
DEATH!
Do not allow the engine or
muffler to come in contact
with flammable vapors, combus
-
tible dust, gases or other com
-
bustible materials. A spark may
cause a fire.
When using the air compressor
for spray painting, place the air
compressor as far away from the
work area as possible, using extra
air hoses if needed.