Filter
Top Products
6
471-1197
K. INDICATIONS OF A FULLY CHARGED BATTERY
A hydrometer reading of the specific gravity of the electrolyte (fluid) of the battery in good condition should be between 1.25 and 1.28.
When a battery reaches 80-85% of full charge, bubbles will appear on the surface of the fluid. As the battery nears full charge, bubbling
will become more vigorous.
The digital display Meter will display FULL when the battery is completely charged.
L. ASSEMBLY INSTRUCTIONS
Wheel Charger assembly instructions:
NOTE: Unit must be fully assembled before operating.
PARTS: TOOLS NECESSARY:
4 10-32 thread cutting screws 5/16" wrench
1 mounting foot Hammer
2 wheels Screwdriver
2 axle caps
2 axle brackets
1 handle
First place the charger on its side.
Next mount the mounting foot FIG. A with (2) 10-32 screws.
Next pound the axle firmly into an axle cap using a hammer, FIG. B.
Next slide the wheels onto the axle, hubs must face in, FIG. C.
Next pound the other axle cap onto the other end of the axle.
Next place the axle assembly onto the bottom of the charger as shows in figure FIG. C. Mount the axle to the bottom of the charger using
the two 10-32 thread cutting screws as shown in Fig. D (these screws require a 5/16" wrench.)
Next turn the battery charger right side up onto its foot and wheels.
Remove the two top screws from each side of the charger, line up the handle and reinstall the screws. FIG. E.
M. TROUBLESHOOTING
1. No meter reading
A. Make sure that the charger is plugged into the AC outlet.
B. Make sure that the AC outlet is "LIVE." Check by plugging in a lamp.
2. Meter displays CHK BAT
A. Have a serviceman, at your neighborhood garage, check that the battery is capable of taking a charge, it may be damaged or
sulfated.
B. Make sure you have selected the proper charge voltage for the battery being charged.
C. After unplugging charger, check the connections at the battery. Make sure the clips are making good contact.
D. If the battery voltage is below 1.5 volts and you were charging in automatic, the display will read CHK BAT. Try to bring the battery
voltage up above the needed 1.5 volts by selecting the MANUAL mode and the 2 amp setting. This should bring the battery voltage
to the needed voltage in a few minutes.
3. Vehicle will not start in ENGINE START
A. Unplug the charger and check the connections at the battery.
B. You must wait until the meter read "RDY." The charger may still be in the "WAIT" mode.
C. The thermal protector may have tripped and needs a little longer to close. Wait a little longer and retry.
D. If the engine turns over, but doesn't start, the problem is with the vehicle, not the charger. Have the vehicle problem resolved
before you try to crank the engine again.
N. WARRANTY
SCHUMACHER ELECTRIC CORPORATION, 801 BUSINESS CENTER DRIVE, MOUNT
PROSPECT, ILLINOIS 60056-2179 MAKES THIS LIMITED WARRANTY TO THE ORIGINAL
PURCHASER AT RETAIL OF THIS PRODUCT. THIS LIMITED WARRANTY IS NOT TRANS-
FERABLE.
Schumacher Electric Corporation warrants this battery charger for five years from date of
purchase at retail against defective material or workmanship. If such should occur, the unit will be
repaired or replaced at the option of the manufacturer. It is the obligation of the purchaser to forward
the unit together with proof of purchase, transportation and/or mailing changes prepaid to the manufac-
turer or its authorized representative.
This limited warranty is void if the product is misuse, subjected to careless handling, or
repaired by anyone other than the manufacturer or its authorized representative.
The manufacturer makes no warranty other than this limited warranty and expressly excludes
any implied warranty including any warranty for consequential damages.
THIS IS THE ONLY EXPRESS LIMITED WARRANTY AND THE MANUFACTURER NEI-
THER ASSUMES NOR AUTHORIZES ANYONE TO ASSUME OR MAKE ANY OTHER OBLIGATION
TOWARDS THE PRODUCT OTHER THAN THIS EXPRESS LIMITED WARRANTY. THE MANU-
FACTURER MAKES NO WARRANTY OF MERCHANTABILITY OR FITNESS FOR PURPOSE OF
THIS PRODUCT AND EXPRESSLY EXCLUDES SUCH FROM THIS LIMITED WARRANTY.
SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR
CONSEQUENTIAL DAMAGES OR LENGTH OF IMPLIED WARRANTY SO THE ABOVE LIMITA-
TIONS OR EXCLUSIONS MAY NOT APPLY TO YOU.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER
RIGHTS WHICH VARY FROM STATE TO STATE
Fig. E
AXLE BRACKET
Fig. B
HUBS MUST
FACE IN
Fig. A
Fig. D
—AXLE CAP
Fig. C