Filter
Top Products
14 Portable Gasoline Air Compressor Manual
INITIAL SET-UP:
1. Read safety warnings before setting-up air compressor.
2. Ensure the oil level in the air compressor pump is adequate. If low,
add SAE 30W non-detergent oil.
LOCATION:
1. In order to avoid damaging the air compressor, do not incline the air
compressor transversely or longitudinally more than 10°.
2. Place air compressor at least 12 inches away from obstacles that may
prevent proper ventilation. Do not place air compressor in an area:
-where there is evidence of oil or gas leaks.
-where flammable gas vapors or materials may be present.
-where air temperatures fall below 32°F or exceed 104°F.
-where extremely dirty air or water could be drawn into the air
compressor.
GASOLINE ENGINE:
1. Review "Risk of Fire or Explosion" pg. 4 before fueling.
2. Read the engine manual accompanying this air compressor for correct
engine start-up maintenance procedures.
3. Read and understand the safety labels located on the air compressor.
4. A minimum of 86 octane fuel is recommended for use with this air
compressor. Do not mix oil with gasoline.
5. Use of clean, fresh, lead free gasoline is recommended. Leaded gasoline
may be used if lead free is not available. Do not use gasoline containing
methanol or alcohol.
6. Check the engine oil level before starting. (See engine manual.)
7. Fill the fuel tank according to the engine manual instruction.
8. Refer to the engine manual for all necessary maintenance and
adjustments.
PRE-START CHECKLIST:
1. Check oil level. Add if necessary.
2. Remove any moisture in the air compressor air tank. NEVER attempt to
open the Air Tank Drain Valve when more than 10 PSI of air
pressure is in the air tank! Remove excessive pressure with an
air tool, then open the Air Tank Drain Valve in the bottom of the air tank.
Close tightly when drained.
3. Make sure the Engine Switch is in the "OFF" position.
4. Make sure the Safety Relief Valve is working correctly.
5. Make sure all guards and covers are in place and securely mounted.
PREPARATION
WARNING
RISK OF BODILY INJURY!
Never attempt to open the
Air Tank Drain Valve when
more than 10 PSI of air
pressure is in the air tank!
WARNING
RISK OF EXPLOSION OR FIRE
CAUSING SERIOUS INJURY
OR DEATH!
Do not allow the engine or
muffler to come in contact
with flammable vapors, com-
bustible dust, gases or other
combustible materials. A
spark may cause a fire.
When using the air compres-
sor for spray painting, place
the air compressor as far
away from the work area as
possible, using extra air hoses
if needed.
DANGER
RISK OF EXPLOSION OR FIRE
CAUSING SERIOUS INJURY
OR DEATH!
Do not smoke while fueling!
Do not fill fuel tank while air
compressor is running or hot.
Allow air compressor and
engine to cool down for two
minutes before refueling.
Do not fill fuel tank to point
of overflowing. Allow
approximately 1/4" of tank
space for fuel expansion.
WARNING
RISK OF EXPLOSION OR FIRE
CAUSING SERIOUS INJURY
OR DEATH!
Do not place unit in an area
where flammable gas vapors
may be present. A spark could
cause an explosion or fire.
Always store fuel away from
the air compressor while it is
running or hot.
WARNING
RISK OF ASPHYXIATION!
Do not operate in an enclosed
area. Use this product only
in well ventilated areas! The
exhaust from the engine
contains carbon monoxide,
a poisonous, odorless and
invisible gas. Breathing the
gas can cause serious injury,
illness and possible death.