Filter
Top Products
EHTX44Y5 RIDE-ON TROWEL • OPERATION MANUAL — REV. #0 (01/16/13) — PAGE 31
Oil And Fuel Lines
1. Check the oil and fuel lines and connections regularly
for leaks or damage. Repair or replace as necessary.
2. Replace the oil and fuel lines every two years to
maintain the line's performance and flexibility.
CHECKING THE V-BELT
The V-belt (Figure 27) needs to be replaced as soon as it
starts to show signs of wear. NEVER use a defective V-belt
under any circumstances. Indications of excessive belt wear
are fraying, squealing when in use, a belt that emits smoke
or a burning rubber smell when in use.
Figure 27. V-Belt Inspection
1. Visually inspect V-belt (Figure 27) for signs of damage
or excessive wear. If V-belt is worn or damaged, replace
V-belt.
2. Check to ensure that the V-belt is tensioned and aligned
correctly.
GLAZED
OIL SOAKED
BROKEN
CORD FAILURE
CRACKS
MISSING RUBBER
SIDEWALL
WEAR
WORN BACK
COVER
MAINTENANCE
Battery/Charging System
1. Check and clean battery terminals for corrosion.
2. Check and keep battery electrolyte between upper and
lower limits indicated on the battery. Never operate or
recharge without sufficient fluid in the battery.
3. Never attempt to charge a battery that is frozen. The
battery can explode unless first allowed to thaw.
4. Disconnect the negative terminal ( - ) of the battery
during storage. If unit will be stored where ambient
temperature will drop to -15
o
C or less, remove and
store battery in a warm, dry place
Long Term Storage
Remove the battery.
Drain the fuel tank completely. Treat with a fuel stabilizer
if necessary.
Clean exterior with a cloth soaked in clean oil.
Store unit covered with plastic sheet in moisture and
dust-free location out of direct sunlight.
DANGER
Use all safety precautions specified by the battery
manufacturer when working with the battery.
Flammable, explosive gas. (produces
hydrogen gas while charging or during
operation). Keep area around battery well
ventilated and keep from any fire source.
Battery electrolyte contains corrosive, toxic
chemical. (dilute sulfuric acid). Avoid
contact with eyes and skin.
Shock or Fire due to electric short-
circuit. Disconnect battery cables before
inspecting electrical system and never
"spark" battery terminals to test for charge.
CAUTION
NEVER store the ride-on trowel with fuel in the tank for
any extended period of time. Always clean up spilled
fuel immediately.