Filter
Top Products
. Complete Parts List available at www. MillerWelds.com
OM-228 042 Page 40
Trouble Remedy
Engine will not start. Check fuel level (see Section 5-3).
Move choke control to correct position (see Section 6-1).
Open fuel valve (see Section 5-3). Close fuel valve before moving unit or carburetor may flood and make
starting difficult.
Be sure engine switch is On.
Check oil level (see Section 5-3). Engine stops if oil level is too low. Refill crankcase with proper viscosity
oil for operating temperature.
Have Factory Authorized Service Agent check low oil level shutdown switch.
Check battery voltage (electric start models only).
Check battery connections and tighten if necessary (electric start models only).
Engine stopped during normal
operation.
Check fuel level (see Section 5-3).
Open fuel valve (see Section 5-3). Close fuel valve before moving unit or carburetor may flood and make
starting difficult.
Check oil level (see Section 5-3). Engine stops if oil level is too low.
Unstable or sluggish engine speeds. Check engine speed, and adjust if necessary (see Section 8-10).
Check throttle/governor linkage for smooth, non-binding operation.
Tune-up engine according to engine manual.
Battery discharges between uses (Elec-
tric Start Models Only).
Clean battery terminals and posts with baking soda and water solution; rinse with clear water.
Periodically recharge battery (approximately every 3 months).
Replace battery.
Check engine battery charging circuit and connections according to engine manual.
SECTION 10 − PARTS LIST
. A complete parts list is available at www.MillerWelds.com.
10-1. Recommended Spare Parts
Description
Part
No.
Recommended Spare Parts
Quantity
221581 Tune−up & Filter Kit, Kohler (Includes) 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
203960 Spark Plug, Kohler (CS8/10/12) 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
221579 Air Filter, Kohler (CS10−recoil) 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
221580 Air Filter Pre−cleaner, Kohler (CS10−recoil) 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
169715 Nozzle, Slip Type .500 Orf Flush 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
087299 Tip, Contact Scr .023 Wire X 1.125 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
000067 Tip, Contact Scr .030 Wire X 1.125 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
000068 Tip, Contact Scr .035 Wire X 1.125 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
000069 Tip, Contact Scr .045 Wire X 1.125 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
194010 Liner, Monocoil .023/.025 Wire X 15ft (Consisting Of) 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
194011 Liner, Monocoil .030/.035 Wire X 15ft (Consisting Of) 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
194012 Liner, Monocoil .035−.045 Wire X 15 ft (Consisting Of) 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
079975 O-ring, .187 Id X .103cs Rbr 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .