Filter
Top Products
2
308–293
Table
of Contents
Warnings
2
.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Selection
Charts
4.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air
Flow and Atomizing Pressure
7.
. . . . . . . . . . . . . . . .
Typical
Installation
8.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Setup 9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation 13
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Daily
Gun Care, Flushing, and Cleaning
14.
. . . . . . . . .
Troubleshooting 18
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service 20
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Part
Drawing
24.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts
List
25.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Accessories 26
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Technical
Data
28.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warranty 32
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Symbols
Warning Symbol
WARNING
This
symbol alerts you to the possibility of serious
injury or death if you do not follow the instructions.
Caution Symbol
CAUTION
This
symbol alerts you to the possibility of damage to
or destruction of equipment if you do not follow the
instructions.
WARNING
INSTRUCTIONS
EQUIPMENT MISUSE HAZARD
Equipment
misuse can cause the equipment to rupture, malfunction or start unexpectedly and result in
serious injury
.
D
This equipment is for professional use only
.
D
Read all instruction manuals, tags, and labels before operating the equipment.
D
Use the equipment only for its intended purpose. If you are uncertain about usage, call your Graco
distributor.
D
Do not alter or modify this equipment. Use only genuine Graco parts and accessories.
D
Check equipment daily
. Repair or replace worn or damaged parts immediately
.
D
Use this equipment only in low pressure, air spray systems.
D
Do not exceed the maximum working pressure of the lowest rated system component. This equip
-
ment has a
100 psi (0.7 MPa, 7 bar) maximum working fluid and air pressure
.
D
Route the hoses away from the traffic areas, sharp edges, moving parts, and hot surfaces. Do not
expose Graco hoses to temperatures above 180
_F (82_
C) or below –40
_F (–40_C).
D W
ear hearing protection when operating this equipment.
D
Use fluids or solvents that are compatible with equipment wetted parts. See the
T
echnical Data
section of all equipment manuals. Read the fluid and solvent manufacturer
’
s warnings.
D
Methylene Chloride with formic or propionic acid is not recommended as a flushing or cleaning
solvent with this gun or any other device with nylon or aluminum components as it can damage
these parts.
D
Comply with all applicable local, state and national fire, electrical and other safety regulations.